衝壓板拉伸應變痕缺陷分析及改進(一)

衝壓板拉伸應變痕缺陷分析及改進(一)

Dec 13, 2023

免責聲明:本文援引自網絡或其他媒體,與揚鍛官網無關。其原創性以及文中陳述文字和內容未經本站證實,對本文以及其中全部或者部分內容、文字的真實性、完整性、及時性本站不作任何保證或承諾,請讀者僅作參考,並請自行核實相關內容。

轉發自:河北冶金

作者:楊西鵬',何 方',安春文,程 迪,王連軒,杜豔玲'(1.河北鋼鐵集團 邯鋼公司 技術中心,河北 邯 056015;2.河北鋼鐵集團 邯鋼公司

 ANALYSIS AND IMPROVEMENT FOR

DEFECT OF TENSION STAIN TRACE ON STAMPING SHEET

Yang Xipeng l , He Fang l , An Chunwen , Cheng Di l , Wang Lianxuan , Du Yanling

( 1. Technique Center, Handan Iron and Steel Company, Hebei Iron and Steel Group, Handan, Hebei, 056015 ; 2. Hanbao Company, Handan Iron and Steel Company, Hebei Iron and Steel Group, Handan, Hebei, 056015)

Abstract: The tension strain trace defect is got on the surface of the cold — rolling sheet after stamping and it would affect the customer S application. With examination, investigation and analysis for samples of normal sheet and the defect sheet, it is confirmed that the defects is caused by the yield plane in steel sheet, which is brought about because of not enough tempering elongation at welding gap when passing exit of continuous annealing line and then the sheet being not fully cutting off. With optimizing temper mill and exit head — tail cutting — off process parameters to eliminate the part of sheet with unqualified tempering elongation, the tension strain trace would not be brought about on the sheet when used by customers. Key Words: stamping sheet; tension strain trace; defect; analysis; improvement

1 1

總第217期 HEBEI YEJIN

I . 1力學性能

在拉力試驗機上對樣品鋼板進行力學性能檢測,結果見表1,試驗標距為橫向80 mm 1 #試樣為正常樣板,2 #試樣為拉伸應變痕樣板。由表1可以看出,1 #試樣沒有出現屈服平台,而2 #試樣有明顯 表2粗糙度對比

Tab. 2 Contrast of roughness

粗糙度

1 #試樣

2 #試樣 1、534

伍866 1、695

0 “ 829 l . 403

o、921

的(de)屈服平台(見圖2)。由圖2可以看出,2 #試樣存 I . 3顯微組織

在明顯的屈服現象。

表1冷軋板試樣的力學性能對比

Tab. 1 Contrast of mechanical properties Of cold一rolling sheet test sample

上屈服強下度/MPa 屈服強抗拉強

Rpo 2/MPa延伸率/%度/MPa度/MPa

1 #試樣 355,4

356.8 233.7

232巧 35.36

36.79

2 #試樣 245、2

249,7 237、1

23 & 4 352巧

353、4 243.0

245,9 40.41

39,71

145·0《 95乞335

1#試樣

it i i 可《00一

刃2 145@伽刃 952.335

、.0;.然丿å 2#試樣

圖2冷軋板的拉伸曲線

Fig. 2 Tension curve of cold一rolling sheet

I . 2粗糙度通過對試樣的粗糙度檢測,發現1 #試樣的粗糙度明顯高於2 #試樣。檢測數據如表2所示,粗糙度有明顯差異,反映出1 #試樣的平整機軋製力要大於 2 #試樣的軋製力,說明1 #試樣的(de)平整延伸率要大於當鋼板表層鐵素體品粒大小不均勻時,鋼板在衝壓過程中晶粒取向不同,變形量差異較大,品粒受力不均勻是導致衝壓件表麵產生拉伸應變痕缺陷的(de)根源0為此,對冷軋板樣品進行了顯微組織觀察,如圖3所示。2個試樣表層組織和芯部組織基本一致,組織較為均勻,再結晶充分,品粒度大小為 10巧1級,無異常組織。

50

1#試樣芯部

{ 50

ml

2#試樣芯部

50 m

1#試樣表層

2 #試樣。

河北冶全 2014年第1期

上4表麵形貌經掃描電鏡觀察,1 #試樣的板帶有均勻明顯的毛化坑,明暗交替線明顯;而2 #試樣的板帶毛化坑不明顯,毛化坑較淺,明暗交替線較暗

淺談杜邦分析法的缺陷與改進(二)
衝壓板拉伸應變痕缺陷分析及改進(二)
网站地图 草莓视频污在线观看-草莓视频IOS-草莓视频下载IOS-草莓视频黄色